Safety Recall NHTSA · 11V091000 Reported February 11, 2011

Evaporators/possible overheating/trans air

Q: What is recall 11V091000?

NHTSA recall 11V091000 was issued by Double K Inc. on February 11, 2011. It addresses: Evaporators/possible overheating/trans air. The recall affects approximately 175 vehicles , with the defect involving the N/A component.

Q: Is my vehicle included in this recall?

The only way to confirm is to look up your 17-character VIN at nhtsa.gov/recalls . NHTSA's tool will tell you if VIN-by-VIN this exact recall applies.

Q: How long do I have to get a recall repair done?

There is no expiration on most federal safety recalls. Even if your vehicle is years old and you bought it used, the manufacturer is required to perform the repair at no cost.

Double K Inc. · N/A · 175 vehicles potentially affected

NHTSA ID

11V091000

Manufacturer Campaign

NR (Not Reported)

Manufacturer

Double K Inc.

Component

N/A

Vehicles Affected

175

Recall Type

Vehicle

Report Received

February 11, 2011

Defect Summary

Double k is recalling certain buses equipped with trans air ta 73 evaporators. the evaporator utilizes a power resistor to regulate blower speed. Should a short occur in the "low or medium speed" circuit while the blower is in high speed, the short will cause the supply voltage to feedback through the resistor to ground, not drawing enough current to trip the fuse.

Safety Consequence

This would cause the resistor temperature to rise to a point where it will melt and possibly ignite the plastic blower housing to which it is mounted. the overheating can result in a fire.

Corrective Action

Double k in cooperation with trans air will install a thermal shutdown device in series with the speed resistors. this service will be performed free of charge. the safety recall began during february 2011. owners may contact trans air warranty and service center at 1-800-673-2446 and double k at 1-715-478-5090.

What you should do

Look up your VIN at nhtsa.gov/recalls to confirm this recall applies to your vehicle.
Contact an authorized Double K Inc. dealer and reference recall ID 11V091000 or campaign NR (Not Reported).
Schedule the free repair. By federal law, the manufacturer must remedy the defect at no cost.

View Official NHTSA Notice →

Similar Recalls

Other recalls from Double K Inc. or involving N/A.

Recall 26V290000

Chrysler (fca Us, Llc)

Power transfer unit may fail and cause a loss of drive power

N/A · 61,711 affected · May 7, 2026

Recall 73V092000

Harley-davidson Motor Company

Brakes:mechanical service:other

N/A · 2,607 affected · Apr 30, 1973

Recall 73V094000

Harley-davidson Motor Company

Suspension

N/A · 11,705 affected · Apr 30, 1973

Recall 26T011000

Goodyear Tire & Rubber Company

Tire tread may separate

N/A · 69 affected · Apr 18, 2026

Recall 26E021000

Chrysler (fca Us, Llc)

Engine failure may cause fire or loss of drive power

N/A · 2,689 affected · Apr 16, 2026

FAQ: Recall 11V091000

Your rights, the repair process, and what each field on this page means.

What is recall 11V091000?

NHTSA recall 11V091000 was issued by Double K Inc. on February 11, 2011. It addresses: Evaporators/possible overheating/trans air. The recall affects approximately 175 vehicles, with the defect involving the N/A component.

How do I get this recall repaired?

Contact any authorized Double K Inc. dealer and reference NHTSA recall ID 11V091000 or the manufacturer campaign number NR (Not Reported). Under federal law, the repair is completely free regardless of vehicle age or owner history.

Is my vehicle included in this recall?

The only way to confirm is to look up your 17-character VIN at nhtsa.gov/recalls. NHTSA's tool will tell you if VIN-by-VIN this exact recall applies.

How long do I have to get a recall repair done?

There is no expiration on most federal safety recalls. Even if your vehicle is years old and you bought it used, the manufacturer is required to perform the repair at no cost.

Where does the data on this page come from?

All information on this page is sourced directly from the U.S. Department of Transportation public dataset for NHTSA recalls. Last refreshed: 2026-05-22. For the most current official notice, visit nhtsa.gov/recalls.