Engine cover may be excessively hot
Defect Summary
Ford motor company (ford) is recalling certain 2021 e-350 and e-450 vehicles. the underside of the engine cover may have mispositioned insulation, allowing the cover to get excessively hot.
Safety Consequence
Direct and continuous contact with certain areas of engine cover surface in the passenger compartment may increase the risk of injury or burns to the skin of the driver or front seat passenger.
Corrective Action
Ford will notify owners, and dealers will inspect the engine cover for gaps between the rubber seal and the insulation. If gaps are present, the dealer will install engine cover insulation patches in the right hand and left hand inner lower corners of the engine cover. The dealer will also update the powertrain calibration for heat management under elevated idle conditions should a vehicle be equipped with seic or bcp, free of charge. the recall began february 15, 2021. owners may contact ford customer service at 1-866-436-7332. ford's number for this recall is 20s73.
Similar Recalls
Other recalls from Ford Motor Company or involving N/A.
FAQ: Recall 20V795000
Your rights, the repair process, and what each field on this page means.
What is recall 20V795000?
NHTSA recall 20V795000 was issued by Ford Motor Company on December 17, 2020. It addresses: Engine cover may be excessively hot. The recall affects approximately 29,344 vehicles, with the defect involving the N/A component.
How do I get this recall repaired?
Contact any authorized Ford Motor Company dealer and reference NHTSA recall ID 20V795000 or the manufacturer campaign number 20S73. Under federal law, the repair is completely free regardless of vehicle age or owner history.
Is my vehicle included in this recall?
The only way to confirm is to look up your 17-character VIN at nhtsa.gov/recalls. NHTSA's tool will tell you if VIN-by-VIN this exact recall applies.
How long do I have to get a recall repair done?
There is no expiration on most federal safety recalls. Even if your vehicle is years old and you bought it used, the manufacturer is required to perform the repair at no cost.
Where does the data on this page come from?
All information on this page is sourced directly from the U.S. Department of Transportation public dataset for NHTSA recalls. Last refreshed: 2026-05-22. For the most current official notice, visit nhtsa.gov/recalls.