NHTSA Recall History
Gillig, Llc Safety Recalls
Every NHTSA-recorded safety recall issued by Gillig, Llc — searchable by year, component, and severity. Data sourced daily from the U.S. Department of Transportation.
⚠ 1 active Do Not Drive recall — see below
About Gillig, Llc recalls
Gillig, Llc has issued 126 NHTSA-tracked safety recalls spanning 36 years (from 1970 to 2026), affecting an estimated 163,733 vehicles. The most-recalled components are Electrical System, Steering, Suspension. Repairs for active recalls are free at any authorized Gillig, Llc dealer — there is no time limit on safety recalls.
Defect Categories
Most-recalled components
The vehicle systems behind most Gillig, Llc safety recalls.
Electrical System 15 recalls
Steering 14 recalls
Suspension 9 recalls
Structure 8 recalls
Power Train 8 recalls
Engine And Engine Cooling 8 recalls
Recall History
Gillig, Llc recalls by year
Browse 126 recalls across 36 years. Most recent first.
2026 3 recalls
Recall 26V190000
Gillig, Llc
Gawr on federal placard may exceed tire load rating/fmvss 120
Equipment · 6 affected · Mar 26, 2026
Recall 26V144000
Gillig, Llc
High voltage cable may overheat
Electrical System · 424 affected · Mar 12, 2026
Recall 26V142000
Gillig, Llc
Intake pipe may contact the fuel line
Fuel System, Diesel · 3,568 affected · Mar 12, 2026
2025 5 recalls
Recall 25V913000
Gillig, Llc
Improperly tightened rear axle upper torque rod fasteners
Suspension · 26 affected · Dec 29, 2025
Recall 25V870000
Gillig, Llc
Wheelchair restraint retractor may not lock
Equipment Adaptive/mobility · 4 affected · Dec 16, 2025
Recall 25V868000
Gillig, Llc
Emergency exit window latch may fail/fmvss 217
Structure · 6 affected · Dec 15, 2025
Recall 25V203000
Gillig, Llc
High voltage batteries may short circuit
Electrical System · 27 affected · Apr 1, 2025
Recall 25V076000
Gillig, Llc
Flat panel display monitor may detach from ceiling
Equipment · 91 affected · Feb 11, 2025
2024 6 recalls
Recall 24V958000
Gillig, Llc
Damaged fire suppression relay cable may fail
Electrical System · 201 affected · Dec 20, 2024
Recall 24V959000
Gillig, Llc
Hv air compressor is not on protective hvil loop
Electrical System · 332 affected · Dec 20, 2024
Recall 24V921000
Gillig, Llc
Odometer malfunction in ev mode/fmvss 101
Electrical System · 9 affected · Dec 11, 2024
Recall 24V811000
Gillig, Llc
Defective weld may cause wipers to fail/fmvss 104
Visibility · 611 affected · Oct 29, 2024
Recall 24V514000
Gillig, Llc
Loss of steering control from loose steering shaft
Steering · 1,189 affected · Jul 5, 2024
Recall 24V390000
Gillig, Llc
Remote fuel filter hoses may disconnect and leak
Fuel System, Diesel · 54 affected · Jun 3, 2024
2023 8 recalls
Recall 23V809000
Gillig, Llc
Inadequate rear axle hub lubrication
Power Train · 34 affected · Dec 4, 2023
Recall 23V812000
Gillig, Llc
Incorrect fuse may overheat and cause fire
Electrical System · 3,626 affected · Dec 4, 2023
Recall 23V740000
Gillig, Llc
Transmission may separate from driveshaft
Power Train · 4,286 affected · Nov 3, 2023
Recall 23V635000
Gillig, Llc
Loose fasteners may allow driveshaft to detach
Power Train · 223 affected · Sep 14, 2023
Recall 23V356000
Gillig, Llc
Electrical short-circuit in fuse box
N/A · 30 affected · May 18, 2023
Recall 23V124000
Gillig, Llc
Lower control arm may fail
Suspension · 435 affected · Feb 24, 2023
Recall 23V075000
Gillig, Llc
Incompatible steering system draglink
Steering · 1,335 affected · Feb 10, 2023
Recall 23E013000
Gillig, Llc
Rear suspension torque rod incompatible
Suspension · 487 affected · Feb 10, 2023
2022 4 recalls
Recall 22V801000
Gillig, Llc
Steering shaft may stick causing loss of control
N/A · 388 affected · Oct 24, 2022
Recall 22V548000
Gillig, Llc
Battery pack may short and cause fire
Electrical System · 184 affected · Jul 28, 2022
Recall 22V436000
Gillig, Llc
Ev system may switch into neutral unexpectedly
Electrical System · 169 affected · Jun 17, 2022
Recall 22V276000
Gillig, Llc
Rear mounted ultracapacitors improperly programmed
Electrical System · 592 affected · Apr 25, 2022
2021 6 recalls
Recall 21V705000
Gillig, Llc
Shutdown override switch may not function
N/A · 15 affected · Sep 10, 2021
Recall 21V563000
Gillig, Llc
Fuel hose leak
Fuel System, Diesel · 148 affected · Jul 23, 2021
Recall 21V538000
Gillig, Llc
Excessive ammonia in tailpipe exhaust
Engine And Engine Cooling · 78 affected · Jul 15, 2021
Recall 21V487000
Gillig, Llc
Misaligned rear axle
Suspension · 86 affected · Jun 28, 2021
Recall 21V352000
Gillig, Llc
High pressure fuel rail assembly may leak fuel
Fuel System, Diesel · 4,428 affected · May 14, 2021
Recall 21V291000
Gillig, Llc
Roof door may accidentally open
Structure · 229 affected · Apr 23, 2021
2020 5 recalls
Recall 20V392000
Gillig, Llc
Loss of power steering assist
Steering · 531 affected · Jul 2, 2020
Recall 20E035000
Gillig, Llc
Rear suspension lowercontrol rod failure
Suspension · 6,353 affected · Jun 12, 2020
Recall 20V342000
Gillig, Llc
Rear suspension lower control rod failure
Suspension · 3,728 affected · Jun 10, 2020
Recall 20V239000
Gillig, Llc
Pressure relief devices may not vent/fmvss 304
Fuel System, Other · 275 affected · Apr 29, 2020
Recall 20V179000
Gillig, Llc
Incorrect circuit breaker can result in short
Electrical System · 8,224 affected · Mar 25, 2020
2019 4 recalls
Recall 19E041000
Gillig, Llc
Roof hatch glass may shatter
Structure · 7 affected · Jun 19, 2019
Recall 19V451000
Gillig, Llc
Roof hatch glass may shatter
Structure · 25 affected · Jun 14, 2019
Recall 19V193000
Gillig, Llc
Loss of headlights from short circuit
Exterior Lighting · 965 affected · Mar 8, 2019
Recall 19V059000
Gillig, Llc
Ball stud improperly torqued
Steering · 3,659 affected · Jan 28, 2019
2018 6 recalls
Recall 18V886000
Gillig, Llc
Blocked emergency exit may hinder passenger exit
Structure · 30 affected · Dec 12, 2018
Recall 18E113000
Gillig, Llc
Fire suppression system may not discharge
N/A · 33 affected · Dec 11, 2018
Recall 18V789000
Gillig, Llc
Loose spring cage bolts may cause vehicle rollaway
Parking Brake · 4,469 affected · Nov 9, 2018
Recall 18V665000
Gillig, Llc
Loss of drive from broken transmission switch
Power Train · 90 affected · Sep 25, 2018
Recall 18V511000
Gillig, Llc
Incorrect turn signal flash pattern/fmvss 108
Exterior Lighting · 178 affected · Aug 9, 2018
Recall 18V418000
Gillig, Llc
Turn signal flashing rate incorrect/fmvss 108
Exterior Lighting · 25,579 affected · Jun 20, 2018
2017 6 recalls
Recall 17V559000
Gillig, Llc
Loss of power steering assist
Steering · 108 affected · Sep 8, 2017
Recall 17V519000
Gillig, Llc
Seat belt buckle stuck in the locked position
N/A · 3,432 affected · Aug 23, 2017
Recall 17V263000
Gillig, Llc
Suspension may lower unexpectedly
N/A · 2,604 affected · Apr 19, 2017
Recall 17V156000
Gillig, Llc
Wiper arms may crack and detach from vehicle
N/A · 2,732 affected · Mar 9, 2017
Recall 17V119000
Gillig, Llc
Visibilty of turn signals/fmvss 108
Exterior Lighting · 17,056 affected · Feb 24, 2017
Recall 17V099000
Gillig, Llc
Visibilty of turn signals and reflectors/fmvss 108
Exterior Lighting · 2,787 affected · Feb 14, 2017
2016 6 recalls
Recall 16V931000
Gillig, Llc
Gas detection system malfunction
N/A · 451 affected · Dec 23, 2016
Do Not Drive 16V701000
Gillig, Llc
Insufficient grease at axle wheel ends
Power Train · 143 affected · Sep 29, 2016
Recall 16V662000
Gillig, Llc
Rear brake hoses can rub on the chassis and fray
Service Brakes, Air · 34 affected · Sep 14, 2016
Recall 16V451000
Gillig, Llc
Stop lamp activation/fmvss 108
Exterior Lighting · 112 affected · Jun 21, 2016
Recall 16V320000
Gillig, Llc
Driver's window may block too much light/fmvss 205
Visibility · 34 affected · May 18, 2016
Recall 16V011000
Gillig, Llc
Missing j-bracket welds on bus operator seat
N/A · 6,734 affected · Jan 13, 2016
2015 9 recalls
Recall 15V888000
Gillig, Llc
Drain hole orientation in front brake chamber
N/A · 16 affected · Dec 30, 2015
Recall 15E092000
Gillig, Llc
Wheel chair lift link arm pivot holes
N/A · 4 affected · Nov 19, 2015
Recall 15V420000
Gillig, Llc
Electrical power cable may chafe on fuel line
Electrical System · 6,971 affected · Jul 1, 2015
Recall 15V295000
Gillig, Llc
Taillight bracket may separate from bus body
Exterior Lighting · 263 affected · May 19, 2015
Recall 15V262000
Gillig, Llc
Vent tube may detach from engine breather
Engine And Engine Cooling · 1,101 affected · May 5, 2015
Recall 15V219000
Gillig, Llc
Air brake hoses may rub causing air leak
Service Brakes, Air · 623 affected · Apr 14, 2015
Recall 15E024000
Gillig, Llc
Seat belt may not properly restrain driver
N/A · 1 affected · Mar 25, 2015
Recall 15E009000
Gillig, Llc
Inconsistent output from hydraulic steering pump
Steering · 177 affected · Feb 18, 2015
Recall 15E010000
Gillig, Llc
Wheelchair lift - platform cracking
N/A · 4 affected · Feb 18, 2015
2014 7 recalls
Recall 14V547000
Gillig, Llc
Air brake supply lines crossed/fmvss 121
N/A · 90 affected · Sep 10, 2014
Recall 14V521000
Gillig, Llc
Fuel filter shell may separate and cause stall
N/A · 231 affected · Aug 28, 2014
Recall 14V459000
Gillig, Llc
Rear brakes missing quick release valve/fmvss 121
Service Brakes, Air · 252 affected · Jul 28, 2014
Recall 14V358000
Gillig, Llc
Hose may leak oil and result in fire
Engine And Engine Cooling · 648 affected · Jun 23, 2014
Recall 14V222000
Gillig, Llc
Electrical harness connector may corrode
Electrical System · 2,274 affected · Apr 25, 2014
Recall 14E018000
Gillig, Llc
Accelerator return springs may fail prematurely
Vehicle Speed Control · 98 affected · Apr 21, 2014
Recall 14V084000
Gillig, Llc
Ice may form in intake manifold
Engine And Engine Cooling · 643 affected · Feb 27, 2014
2012 1 recall
2011 3 recalls
2009 3 recalls
2008 2 recalls
2007 3 recalls
2006 1 recall
2005 4 recalls
Recall 05V473000
Gillig, Llc
Ecm calibration/exhaust temperature sensor
Engine And Engine Cooling · 5 affected · Oct 12, 2005
Recall 05V478000
Gillig, Llc
Engine stall condition/cummins
Fuel System, Other · 34 affected · Oct 12, 2005
Recall 05V271000
Gillig, Llc
Front axle rod/tenneco
Suspension · 1,096 affected · Jun 9, 2005
Recall 05V106000
Gillig, Llc
Burner tubes/webasto
N/A · 10 affected · Mar 17, 2005
2004 7 recalls
Recall 04V610000
Gillig, Llc
Gillig/arvin-meritor/front axle tie rod clamp
Steering · 324 affected · Dec 28, 2004
Recall 04V500000
Gillig, Llc
Gillig/sure-lock/wheelchair securements
N/A · 242 affected · Oct 14, 2004
Recall 04V485000
Gillig, Llc
Gillig/cummins/oil leak
Engine And Engine Cooling · 149 affected · Oct 7, 2004
Recall 04V486000
Gillig, Llc
Engine turbocharger/series 40/detroit diesel
Engine And Engine Cooling · 810 affected · Oct 7, 2004
Recall 04V470000
Gillig, Llc
Gillig/fail engine turbocharger
Engine And Engine Cooling · 323 affected · Sep 24, 2004
Recall 04V308000
Gillig, Llc
Gillig/hydrogen transducer
N/A · 3 affected · Jun 23, 2004
Recall 04V173000
Gillig, Llc
Gillig/cummins/ecm
N/A · 2 affected · Apr 9, 2004
2003 2 recalls
2002 5 recalls
Recall 02V325000
Gillig, Llc
Gillig/engine compartment insulation
N/A · 2,108 affected · Dec 6, 2002
Recall 02V189000
Gillig, Llc
Gillig/steering gear bolt
Steering · 2,558 affected · Jul 25, 2002
Recall 02V004004
Gillig, Llc
Gillig/throttle control/accelerator pedal
Vehicle Speed Control · 865 affected · Mar 22, 2002
Recall 02V059004
Gillig, Llc
Gillig/vapor/door panel adhesive
Structure · 897 affected · Mar 21, 2002
Recall 02V071003
Gillig, Llc
Gillig/vanner/ battery equalizer
Electrical System · 2,113 affected · Mar 18, 2002
2001 1 recall
2000 2 recalls
1994 1 recall
1993 1 recall
1991 4 recalls
Recall 91V175000
Gillig, Llc
Power train:transmission:automatic:cooling unit an
Power Train · 62 affected · Oct 9, 1991
Recall 91V179000
Gillig, Llc
Power train:transmission:automatic:cooling unit an
Power Train · 62 affected · Oct 9, 1991
Recall 91V180000
Gillig, Llc
Power train:transmission:automatic:cooling unit an
Power Train · 62 affected · Oct 9, 1991
Recall 91V142000
Gillig, Llc
Steering:linkages:link:drag:connection
Steering · 125 affected · Aug 26, 1991
1988 1 recall
1982 1 recall
1981 2 recalls
1980 1 recall
1979 1 recall
1978 2 recalls
1973 2 recalls
Gillig, Llc Recall FAQ
Common questions about Gillig, Llc safety recalls, owner rights, and how to use this tracker.
How many recalls has Gillig, Llc issued?
Gillig, Llc has issued 126 NHTSA-tracked recalls covering approximately 163,733 vehicles since 1970. The most recent recall was reported 2026-03-26.
How do I check if my Gillig, Llc vehicle is under recall?
Enter your 17-character VIN at nhtsa.gov/recalls. NHTSA's lookup tool will list every active recall tied to your specific vehicle, including ones from Gillig, Llc and any sub-brand or component supplier.
Are Gillig, Llc recall repairs free?
Yes. Under federal law (49 U.S.C. § 30120), manufacturers including Gillig, Llc must remedy safety defects at no cost to the owner. Bring the recall notice or NHTSA recall ID to any authorized Gillig, Llc dealer and the repair (or replacement, or refund) is free.
Does Gillig, Llc have any "Do Not Drive" recalls?
Yes — 1 Gillig, Llc recall carry a NHTSA "Do Not Drive" warning, meaning the affected vehicles should not be operated until repaired. Look for the red Do Not Drive badge on individual recall cards below.
Which Gillig, Llc components are most commonly recalled?
The top recalled components for Gillig, Llc are: Electrical System (15), Steering (14), Suspension (9), Structure (8), Power Train (8). Recalls in these categories tend to drive the most repair-campaign volume.
Where does this Gillig, Llc recall data come from?
All data on this page is sourced directly from the U.S. Department of Transportation's public recall dataset (NHTSA), refreshed daily. Last update: 2026-05-22. This site is independent and not affiliated with Gillig, Llc.